登录

  • 登录
  • 忘记密码?点击找回

注册

  • 获取手机验证码 60
  • 注册

找回密码

  • 获取手机验证码60
  • 找回
毕业论文网 > 毕业论文 > 环境科学与工程类 > 环境工程 > 正文

面粉厂生产废水处理工艺初步设计毕业论文

 2021-04-08 10:04  

摘 要

淀粉属多羟基天然高分子化合物,在植物的根、茎和果实中广泛地存。淀粉是食物的主要成分,是食品、造纸、纺织等工业部门的主要原料。

每生产1m3淀粉就要产生15—18m3废水,在淀粉、酒精、味精、柠檬酸等几个较大的化工行业生产中,淀粉废水的总排放量位居首位。淀粉废水中的主要成分为淀粉、蛋白质和糖,在不同的生产工艺之中,废水中的CODCr浓度在3000—20000mg/L之间。这些淀粉废水若不经处理,直接排放进入水体,其中所含的污染物质进入水体后会使水中的溶解氧迅速降低,造成水体因缺氧,进而影响鱼类和其他水生生物的生存,同时还会促使水底的陈腐物质在厌氧条件下分解而产生异味,恶化水体,污染环境,损害人体健康,因此废水必须进行处理。

原水水质:CODCr为,SS为,BOD5为,pH为4.0至5.5。经过本工艺要求达到的标准为:淀粉工业污水污染物排放标准,间接排放出水相应指标:CODCr为,SS为,BOD5为,pH为6至9。实际排污染物间接排放浓度:CODCr为,SS为,BOD5为,pH为6至9。满足排放要求。每吨水的处理费用约为0.84元。

主体工艺流程为:

关键词:淀粉废水、生化处理、UASB、生物接触氧化

ABSTRACT

The starch is a multi-hydroxyl natural high molecular compound, which is widely present in the roots, stems and fruits of the plant. Starch is an important component of food, and is the main raw material of food, chemical industry, paper making, textile and other industrial sectors. The total discharge of starch wastewater in starch, alcohol, gourmet powder and citric acid is the first to produce 1 m3 of wastewater. The main components of the starch wastewater are the starch, the protein and the sugar, and the CODCr concentration in the wastewater is between 2,000 and 20000 mg/ L as the production process is different. if the starch wastewater is directly discharged without treatment, the organic matter contained in the starch can rapidly consume the dissolved oxygen in the water after the organic substances enter the water body, so that the water body can influence the survival of the fish and other aquatic organisms due to the lack of oxygen, At the same time, the organic matter at the water bottom can be decomposed to generate the odor under the anaerobic condition, the water body is degraded, the environment is polluted, and the health of the human body is damaged. So that the waste water must be treated. The quality of raw water: CODCr is 9000mg/ L, SS is 800mg/ L, BOD5 is 5000mg/ L, and the pH is 4.0 to 5.5. The standard of the process is as follows: The standard GB25461-2010 for the emission of pollutants in the industrial sewage of the starch industry is the corresponding index for indirect emission of effluent: the CODCr is 300mg/ L, the SS is 70mg/ L, the BOD5 is 70mg/ L, and the pH is 6 to 9. The indirect emission concentration of the actual discharge pollutants: the CODCr is 240.9 mg/ L, the SS is 12 mg/ L, the BOD5 is 89.3 mg/ L, and the pH is 6 to 9.Meet emission requirements. The treatment cost per ton of water is about 0.84 yuan.

Therefore, the wastewater must be treated.The main process flow is as follows:

starch wastewater → grille → Primary sedimentation→ UASB →Biological contact oxidation →Secondary settling tank → effluent

Key words: starch wastewater, biochemical treatment, UASB, biological contact oxidation

目录

目录 4

第一章 绪论 1

第二章 基础资料 2

2.1设计题目 2

2.2原始资料 2

2.3排放要求 2

第三章 工艺方案分析 3

3.1废水水质分析 3

3.2工艺方案比选 3

3.3 流程说明 5

3.4重点工艺介绍 5

3.4.1格栅 5

3.4.2调节池 6

3.4.3初沉池 6

3.4.4 UASB反应器 6

3.4.5接触氧化池 6

3.4.6二沉池 6

3.4.7污泥浓缩池 6

3.4.8污泥脱水间 6

第四章 主要处理设备和构筑物的设计参数 8

4.1 格栅计算 8

4.2调节池的设计 9

4.2.1设计说明 9

4.2.2设计计算 9

4.3泵房的设计 9

4.3.1设计说明 9

4.3.2设计计算 9

4.4初沉池的设计 10

4.5 UASB反应器 11

4.5.1设计说明 11

4.5.2反应器容积计算 12

4.5.3进水配水系统设计 12

4.5.4三相分离器设计 14

4.6 接触氧化池 15

4.6.1计说明 15

4.6.2设计水质水量 16

4.6.3设计计算 16

4.7鼓风机房设计 17

4.8二次沉淀池 18

4.8.2设计计算 18

4.9污泥部分计算 20

4.9.1集泥井 20

4.9.2污泥重力浓缩池 21

第五章 污水处理厂构筑物高程布置计算 23

5.3高程布置原则 24

第六章 投资估算与效益分析 26

6.1土建费用 26

6.2设备部分 27

6.3运行费用 27

6.5环境效益 28

6.6社会效益 28

6.7经济效益 28

参考文献 30

致谢 32

第一章 绪论

1.1研究背景

在国家愈发重视环保的新政策下,环境保护已受到社会各界和全国人民的重视,对污水进行深度的的治理来保护人类赖以生存家园的重要性越来越大,节能高效的污水处理技术与工艺已能为社会经济的发展起到重大的推动作用。近年来淀粉污水行业的生产设备和技术水平虽然在逐渐提升,但水资源问题依然是纺织淀粉业未来发展面临的重大难题和阻碍。淀粉废水是污染严重、处理难度大的废水,若不经处理直接排放会对环境造成很大的威胁。废水中含有的大量有机物会对水中的生物和微生物造成不良影响,水体自净的能力会大大下降;不经处理的淀粉废水排放到水体还会威胁人体健康;淀粉废水中因含有大量的有机物会破坏水体的生态平衡;高浓度的的淀粉废水还会使水体呈现厌氧状态,近几年来,随着水资源日益匮乏,社会需水量却迅猛增加,导致越来越尖锐的矛盾,淀粉废水的合理化处理越来越成为社会各界的关注热点[1]

1.2处理现状

您需要先支付 80元 才能查看全部内容!立即支付

企业微信

Copyright © 2010-2022 毕业论文网 站点地图